1. Welcome to TRD Forums! A community for Toyota, Lexus, and Scion Enthusiasts. To enjoy all the benefits of the site, we invite you to signup.

Exhaust manifold glowing red hot

Discussion in '7th Gen' started by iamsunnybrook, Jul 29, 2013.

  1. Offline

    iamsunnybrook New Member

    Message Count:
    25
    Likes Received:
    7
    Trophy Points:
    3
    Location:
    SoCal
    Vehicles:
    1995 Toyota Corolla
    My exhaust manifold gets like that after a sustained amount of throttle is applied.

    Came to this conclusion after gassing the car with 1/4 throttle up a mountain road.

    Length of uphill is approximately 3 miles.

    In my opinion, these could be the convicts:

    [IMG]Clogged cat converter.

    O2 sensor is acting up.

    Timing is off.

    But i just smogged the car this January. So the cat might be out of the possible suspects.

    If it was an O2 sensor, the car would be running rich, combusting the excess fuel in the manifold, or somewhere else in the exhaust system. And i would be able to smell it while idling. Would also idle rough.

    So would it be my timing?

    Thanks in advance guys.
  2. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    I don't think this is a problem... obviously, you don't have the heat shield installed. If you pass smog fine, the car isn't extra slow, and you don't have a CEL, then I don't see why it wouldn't get real hot like that!
  3. Offline

    iamsunnybrook New Member

    Message Count:
    25
    Likes Received:
    7
    Trophy Points:
    3
    Location:
    SoCal
    Vehicles:
    1995 Toyota Corolla
    is the heat shield that aluminum piece over the manifold? if i is, then it is on lol
  4. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
    I think anyone's exhaust would get pretty damn hot with a sustained throttle application up a mountain, jus saying.
  5. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    If you can't see 4 pipes, then you have the heat shield. The pipes might glow red, but not the heat shield!
  6. Offline

    iamsunnybrook New Member

    Message Count:
    25
    Likes Received:
    7
    Trophy Points:
    3
    Location:
    SoCal
    Vehicles:
    1995 Toyota Corolla
    So its normal? People are saying im pushing my car too hard. But 1/4 throttle? come on. thats like a sunday drive to church..
  7. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    Well if you only need 1/4 throttle to get up the mountain, it doesn't sound clogged or bogged to me! Can you get it to glow again?
  8. Offline

    rx7rocket2005 Ultimate Part-Out King!

    Message Count:
    952
    Likes Received:
    130
    Trophy Points:
    253
    Vehicles:
    2013 Dodge Dart Rallye Turbo
    Yeah all of the manifolds. Glow we just never see em glow if your cat was glowing then yeah it would be clogged , your fine !
  9. Offline

    iamsunnybrook New Member

    Message Count:
    25
    Likes Received:
    7
    Trophy Points:
    3
    Location:
    SoCal
    Vehicles:
    1995 Toyota Corolla
    Yes i can make it glow if i go up tonight for example.
    It sometimes downshifts to 3rd to pick up some momentum but quickly shifts back

    Haha ok thanks guys! just making sure so i dont blow anything internally.
  10. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
    How did you discover that it was glowing in the first place? Do you always drive up mountains then pop your hood and look at your exhaust?
  11. Offline

    iamsunnybrook New Member

    Message Count:
    25
    Likes Received:
    7
    Trophy Points:
    3
    Location:
    SoCal
    Vehicles:
    1995 Toyota Corolla
    Yeah I pop the hood so the motor cools down quicker.
  12. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
    Ah I see. I wouldn't worry about it. YouTube some dyno runs where the header glows. It's most likely way more extreme than what you see.
  13. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    But it's still glowing even after you've had time to stop and pop the hood? wow.
  14. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
    Well it wouldn't cool down instantly, and it sounds like he pops it as soon as he can.
  15. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    So, what did they say on TN? I haven't been over there for like 2 weeks lol.
  16. Offline

    cBass buffalo bell lover

    Message Count:
    10,347
    Likes Received:
    766
    Trophy Points:
    573
    Location:
    Stockton, CA
    Vehicles:
    2005 Corolla XRS
    i was at TN sunday, more new noobs....
  17. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
  18. Offline

    cBass buffalo bell lover

    Message Count:
    10,347
    Likes Received:
    766
    Trophy Points:
    573
    Location:
    Stockton, CA
    Vehicles:
    2005 Corolla XRS
    not here
  19. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    Not Anymore!!
  20. Offline

    cBass buffalo bell lover

    Message Count:
    10,347
    Likes Received:
    766
    Trophy Points:
    573
    Location:
    Stockton, CA
    Vehicles:
    2005 Corolla XRS
  21. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
  22. Offline

    cBass buffalo bell lover

    Message Count:
    10,347
    Likes Received:
    766
    Trophy Points:
    573
    Location:
    Stockton, CA
    Vehicles:
    2005 Corolla XRS
    pffffffhhhhh!!!! your funny
  23. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
  24. Offline

    iamsunnybrook New Member

    Message Count:
    25
    Likes Received:
    7
    Trophy Points:
    3
    Location:
    SoCal
    Vehicles:
    1995 Toyota Corolla
    Said stuff like im running lean and have to check the spark plugs and so on.
  25. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
    It doesn't hurt to check, but I think you'll be fine.
  26. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    I still say get a pic of it glowing.
  27. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
    Well yeah that would be cool. I think I'll try too lol
  28. Offline

    Goldy Well-Known Member

    Administrator
    Message Count:
    32,002
    Likes Received:
    2,874
    Trophy Points:
    61,468
    Vehicles:
    Lexus IS300
    LOL.... don't blow it up now.
  29. Offline

    MacktasticSlick TRD whore with 36,000 posts, bitch

    Administrator
    Message Count:
    36,593
    Likes Received:
    2,274
    Trophy Points:
    61,368
    I drive my car pretty hard everyday lol
  30. Offline

    iamsunnybrook New Member

    Message Count:
    25
    Likes Received:
    7
    Trophy Points:
    3
    Location:
    SoCal
    Vehicles:
    1995 Toyota Corolla
    Haha will do. ;)

Share This Page